Skip to main navigation menu Skip to main content Skip to site footer

Articles

Vol. 13 (2026)

Pores Formation in Al2O3 Crystal during Rapid Solidification under Pressurized Hydrogen Atmosphere

DOI:
https://doi.org/10.31875/2410-4701.2026.13.02
Submitted
April 22, 2026
Published
2026-05-14

Abstract

Rapid solidification of Al2O3 was performed under pressurized hydrogen atmosphere. Many cylindrical pores that arranged in the direction of solidification was formed in the solidified film. The porosity remained constant and was independent of the hydrogen partial pressure. Even at a hydrogen partial pressure of 50%, the amount of hydrogen was sufficient for pore formation. The porosity of the samples prepared in this study was 35% at 0.1 MPa and 30% at 0.6 MPa. The porosity was higher than that of samples prepared by the unidirectional solidification method. The porosity did not depend on the total pressure either. The porosity decreased as the total pressure increased. Pressure is transmitted to the solid-liquid interface via the liquid phase, causing the pressure inside the pores to increase, which results in a decrease in pore size. As the hydrogen partial pressure increased, the thickness of the non-porous layer formed during the early stages of solidification increased slightly. The time required to reach a hydrogen concentration sufficient for pore formation at the solid-liquid interface increases as the hydrogen partial pressure decreases.

References

  1. Ghomashchi MR and Vikhrov A, Squeeze casting: an overview, Journal of Materials Processing Technology 2000 101: 1-9. https://doi.org/10.1016/S0924-0136(99)00291-5
  2. Carroll AF, Thornburg KS and Staten WT, Inhomogeneities in Fused-Cast Alumina, Journal of the Canadian Ceramic Society 1982 51: 43-46.
  3. Yi H, Yang L, Jia L, Huang Y and Cao H, Porosity in Wire-Arc Directed Energy Deposition of Aluminum Alloys: Formation Mechanisms, Influencing Factors and Inhibition Strategies, Additive Manufacturing 2024 84: 104108. https://doi.org/10.1016/j.addma.2024.104108
  4. Yunfei H, Dongjiang W, Dake Z, Fangyong Nand Guangyi M, Investigation of Melt-Growth Alumina/Aluminum Titanate Composite Ceramics Prepared by Directed Energy Deposition, International Journal of Extreme Manufacturing 2021 3: 1-14. https://doi.org/10.1088/2631-7990/abf71a
  5. Nakajima H, Fabrication, Properties and Application of Porous Metals with Directional Pores, Progress in Materials Science 2007 52: 1091-11173. https://doi.org/10.1016/j.pmatsci.2006.09.001
  6. Chilou Z, Yanlei H, Yiran Z and Zhengli H, Hydrogen Permeation Behavior of Rubber Sealing Materials for Hydrogen Infrastructure: Recent Advances and Perspectives, International Journal of Hydrogen Energy 2024 59: 742-754. https://doi.org/10.1016/j.ijhydene.2024.02.042
  7. Ueno S, Lin LM and Nakajima H, Formation Mechanism of Porous Alumina with Oriented Cylindrical Pores Fabricated by Unidirectional Solidification, Journal of the American Ceramic Society 2008 91: 223-226. https://doi.org/10.1111/j.1551-2916.2007.01991.x
  8. Nagashio K, Kodaira K, Kuribayashi K and Motegi T, Spreading and Solidification of a Highly Undercooled Y3Al5O12 Droplet Impinging on a Substrate, International Journal of Heat and Mass Transfer 2008 51: 2455-2461. https://doi.org/10.1016/j.ijheatmasstransfer.2007.08.008
  9. Zhang Y, Huang Bin, Li J, Microstructural Evolution with a Wide Range of Solidification Cooling Rates in a Ni-Based Superalloy, Metallurgical Transactions A 2013 44(4): 1641-1644. https://doi.org/10.1007/s11661-013-1645-7

Similar Articles

1-10 of 15

You may also start an advanced similarity search for this article.